2007 Toyota Tundra Exhaust System Problems
- 10
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- limp mode · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 6 |
| 30–60k mi | 3 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Exhaust System
2 air induction pumps (aip) and associated values failure around 60k miles. According to toyota the reason for the failure is moisture. New pumps and valves can be installed for $4000 or if you are lucky and you only need to replace one pump and both valves it only cost $2150. The new pumps and values have been modified so they should not failure as fast as originals. If the new pumps and valves had to be "modified"…
ODI 10408817
Exhaust System
2007 toyota tundra 4.7l engine p2442 code engine in limp mode. Secondary air intake valve failed in open position. 62000 miles. This is a known defective system that fails if driven in wet conditions due to poor air fan intake design. It sits in the wheel well and is wet all the time. This leads to water being pushed into the air valve causing it to fail. *tr
ODI 10406027
Exhaust System
2007 toyota tundra went into limp mode. Error p2442 reported. 75k miles on truck with air induction system valve sticking due to what appear to be water intrusion. The failure started out intermittently, then became consistent. Cost $1000 to replace both valves in each air induction bank. Worried that the pumps will fail in the near future. Unhappy toyota customer. Poor engineering design. *tr
ODI 10407365
Exhaust System
2007 toyota tundra 4.7. Approximately 124,000 kms engine went inito limp mode. Dealership diagnosed problem as air pump and valve bank failure, $4700 repair estimate. Not covered under warranty because over 100,000 kms. Also purchased extended warranty on this vehicle however these parts are not covered under the extended warranty. (go figure) pursued the emissions warranty which covers emission control parts,…
ODI 10413977
Exhaust System
2007 tundra had a history of loosing power, took it into dealership and they found air injection pump and valve set were rusted and full of water. At a cost of $2000.00, and this is for one side only, the other side can go at any time. I understand these are not updated parts and will need to be replaced again. All out of my pocket. Besides being a safety issue, this a costly repair for what i consider to be a…
ODI 10335726
Exhaust System
2007 toyota tundra has air injection failure which puts the truck in "limp" mode or no power. I was entering the expressway and could not get my truck above 40 miles per hour. I was able to pull onto the shoulder to avoid a major crash. Toyota is aware of the problem but charges $4000 for the repair. My truck has been at the dealer for over 6 weeks. This is due to impart to a national recall. This seems in my…
ODI 10341282
Engine And Engine Cooling · Exhaust System
Air injection system failure causes a check engine light to appear and can cause the vehicle to go into "cripple" mode limiting throttle and speed to 40 mph which could be a serious safety concern in some driving conditions. Dealer stated they are "fixing" ~2 vehicles a day and replacing the air injection pumps and valves for a total cost of ~$4000 if the vehicle is not under warranty anymore. In my case, the dealer…
ODI 10332041
Exhaust System
Vehicle loss of power, unable to pull out safely in traffic. *tr
ODI 10331812
Exhaust System
Toyota tundra 2007 loss power .dealer was testing air pump assy for bank2 and emission control valve for both banks need to be replace .it will cost $ 3000. *tr
ODI 10334742
Equipment · Exhaust System
My wife came very close to getting into an accident while bringing the kids to school a few weeks ago. She was leaving a stop sign getting onto a very busy highway when our 2007 toyota tundra unexpectedly had drastically reduced power. After a trip to the dealership and some research i have found that the reduction in power was caused by a failure in the secondary air injection system. This system is part of the…
ODI 10330863