2000 Toyota Tundra Underbody Shields Problems
- 71
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- cross member · 18 records
- spare tire · 17 records
- frame rust · 13 records
- rear cross · 8 records
- frame corrosion · 6 records
- structure frame · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 19 |
| 60–100k mi | 14 |
| 150–400k mi | 11 |
| 30–60k mi | 7 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Underbody Shields
Abnormal frame rust on 2000 toyota tundra. Upon having a sprayed in bedliner installed to further enhance/preserve our vehicle the installation company advised us they noted a severe amount of frame rust, that was not consistent with the condition of the rest of vehicle. They were under the vehicle for a fire watch during the installation of two welded patches to the truck bed to eliminate rust in the bed before it…
ODI 10293115
Underbody Shields
This is a follow up consumer sent additional information 10/19/09. *nj according to the technician's work order, the rear perches and rear tire carrier were rotted and it was recommended that the vehicle not be driven. Updated voq 10/20/09 *jb consumer wants to know about recall for spare tire on the tundra. 12/15/09 *nj the consumer stated the frame on the vehicle has severe rust. Updated 12/18/09 the consumer…
ODI 10288957
Underbody Shields
Same problem as current action #pe09049. Frame member holding spare tire in 2000 toyota tundra rotted away. Spare tire appeared to be hanging low while truck was parked in the driveway. I went to investigate and when i shook tire to attempt to determine cause the spare tire came crashing to the ground, still attached to part of the frame. Brought truck to toyota dealer the next day to further investigate and they…
ODI 10288706
Suspension · Underbody Shields
I have a 2000 toyota tundra and it is rusted to the point where i cannot get a new inspection sticker. This past weekend i was driving and the spare tire was so badly rusted it broke loose from the mount and nearly caused me to crash as it jammed beneath my vehicle. It then bounced back and almost hit the car behind me. This was a very near miss! I have been fighting with toyota to have them help me with this…
ODI 10287247
Underbody Shields
I have a toyota tundra 2000 with approximately 90,000 miles. It is suffering massive frame rust, especially on the differential and weld points. The spare tire fell off unknown to us sometime last year (2009). The frame is a disaster in the making. Our mechanic is concerned at this rate it may be uninspectable in 1 to 2 years. *tr updated 03/25/10 *bf received pictures. Updated 09/15/10*jb
ODI 10288836
Tank Assembly · Underbody Shields
I have been aware of problems with early model toyota tundra frame rust problems and have followed with interest toyota's response [none]however, i feel obliged to inform you that on friday 25th the gas tank straps failed while driving and the gas tank fell of the vehicle as luck would have it i was slowing down to make a turn so the consequences were limited. But, 30 seconds earlier at 55 mph this most likely would…
ODI 10286047
Underbody Shields
Tl* the contact owns a 2000 toyota tundra. The contact stated that upon routine inspection there was corrosion on the frame. If the frame should fracture while driving there is an increased risk for safety hazard. The manufacturer was contacted. Upon contact a representative stated the tacoma was recalled, but that they would not provide assistance for the tundra. He filed a formal complaint. An adjuster from the…
ODI 10284766
Underbody Shields
2000 toyota tundra. Consumer states that the frame of the vehicle is rotting away. *tgw the consumer stated the cross member was so rusted, that the spare tire dropped from the vehicle and onto the road. *jb
ODI 10321982
Underbody Shields
2000 toyota tundra sr5 truck spare tire fell with under frame holder, and rolled past the vehicle. Dry road summer 2009 , caused by advanced frame corrosion. I brought vehicle to bourne toyota bourne mass to have tire and new holder re- attached to frame, was told they could not do it! *tr updated ivoq 05/25/10.*jb
ODI 10292718
Underbody Shields
Rusting and rotting frame on 2000 toyota tundra. *tr updated 12/30/09 *bf there was a hole in the frame by the rear driver side tire. When the dealer tapped/touched the frame, it fell into pieces. Updated 12/31/09 *jb
ODI 10281881
Underbody Shields
My truck was brought in for a front end alignment and the mechanic brought to my attention that a frame cross member that carries a brake distribution block was rusted away and my brake lines were hanging. Also where my spare was attached was badly rusted. I then went to an auto body shop to inspect the frame. They said that the frame was badly rusted in many other areas that could lead to additional safety…
ODI 10289956
Underbody Shields
I have a 2000 toyota tundra pick up 4 x 4. On both sides of the truck, the frame between the front wheels and front bumper has perforation damage. The front bumper is about to fall off the truck. The rest of the truck frame has extensive rust. *tr
ODI 10474399
Underbody Shields
The frame on my 2000 toyota tundra with only 40,000 miles is completely rotted out!. There are holes in the entirety of the frame the worst of if concentrated under the bed. My truck is virtually useless at this point. It is unable to hold any weight as the frame could break due to the holes and rot on it. I have been told not to put more than 1/2 tank of fuel at a time as the weight could break the rusted out…
ODI 10560758
Underbody Shields
I am concerned about my 2000 toyota tundra. The frame has severe corrosion and there are actually pieces of the rear crossmember missing. The spare tire carrier under the rear of the vehicle came unattached about a year ago and the frame has gotten worse since then. I contacted toyota and they have assigned a file number, however cannot tell me when or if anything will be done. I remember a few years ago when ford…
ODI 10289027
Center Support Bearing · Underbody Shields
Tl* the contact owns a 2000 toyota tundra. The contact stated that while driving at unknown speeds, the vehicle would exhibit excessive shaking. The dealer stated that the vehicle needed new tires. The vehicle was taken to a local mechanic for a second opinion and then taken back to the dealer for further diagnostic testing. The dealer stated that the driveshaft center bearing needed to be replaced. The contact also…
ODI 10328616
Underbody Shields
Tl* the contact owns a 2000 toyota tundra. Upon taking the vehicle for routine maintenance, the mechanic noticed excessive corrosion and holes in the front and rear frame. The dealer verified the corrosion of the frame and advised the vehicle was unsafe to operate. The manufacturer was contacted and advised purchasing a new vehicle. They did not assist. No repairs were made to the vehicle. The failure mileage was…
ODI 10318148
Underbody Shields
2000 toyota tundra failed the routine state inspection. The service writer explained that the truck frame had severe rust/rot perforation damage that resulted in the frame essentially breaking in half. *dt the break in the frame, also broke the rear brake and fuel lines in half. *jb
ODI 10313151
Underbody Shields
I own a 2000 toyota tundra and it has excessive rust and corrosion on the frame of vehicle. Body of the vehicle has no rust. Vehicle has always been maintained, in otherwise great shape. Local toyota dealer indicated that nothing could be done and to contact toyota headquarters. Contacted toyota about the problem (4/08) and received a response that my corrosion warranty ran out 9/05 and they could not do anything…
ODI 10274910
Underbody Shields
2000 toyota tundra. Consumer states problem with frame rust *tgw the dealer informed the consumer the vehicle would be repaired under recall at no cost to him. Several days later, the consumer was then told the recall repair would cost him $1,200.00. The dealer stated that price included additional parts that were needed to replace the frame as they would most likely not be able to be reused, as parts would be…
ODI 10353156
Underbody Shields
2000 toyota tundra sr5. Consumer states experiences with the frame rust and cross member issues. *tgw the consumer stated he was shock to discover the amount of rust that had developed on almost all of the rear frame components.
ODI 10318616
Underbody Shields
Toyota tundra truck recall*cw the consumer read about a recall in the newspaper regarding rust on the rear cross-member. The consumer took his vehicle to the dealer and upon inspection, they discovered rust on the cross-member. *jb updated 03/10/10
ODI 10315439